CJ19系列交流接触器
    CJ19系列交流接触器
    CJ19、CJ19B 及CJ19C 型切换电容器接触器( 以下简称接触器) 都是用于通断低压并联电容器的专用接触器,广泛用于自动补偿的无功功率补偿设备中,适用于交流频率为50Hz,额定工作电压220~380V 的电力系统中通断电容器至60kvar, 以改善功率因数。
    Model CJ19、CJ19B and CJ19C switching capacitor contactors(hereafter called“the contactor“for short)are the coutartors specially used for making and breaking of low voltage shunt capacitors and widely used in reactive power used for making and breaking of capacitor up to 60kvar in electric power system of AC 50Hz and rated working voltage 220~380V for the purpose of power factor.


    结构特征 Structure

      接触器为双断点直动式运动结构,动作机构灵活,手动检查方便,结构紧凑。触头、磁系统采用封闭结构,粉尘不易进入,能提高寿命。接线端均有防护罩覆盖,使用安全可靠。安装可用螺钉紧固,也可扣装在35 毫米或75 毫米的安装轨上,装卸迅速方便。
    Double-break contacts direct-action campaign structure,movement organizations flexible, manually check compact structure. Contact,the magnetic system uses the closed structure,the dust is not easy to enter,can increase life expectancy.Shield terminals are covered,safe and reliable.Install fastening screw can also be installed in the deduction of 35 mm or 75 mm mounting rail,loading and unloading quick and easy.

    外形及安装尺寸图 Outline and installation dimension



    使用条件servicecondition
    1. 环境温度:上限为+40℃,24h 内平均值不超过+35℃;下限为-5℃;
    2. 海拔:不超过2000m;
    3. 大气条件:在最高周围空气温度为+40℃时不超过50%;在较低的温度下允许有较高的相对湿度,最湿月的月平均最低温度不超过 +25℃,该月的月平均最大相对湿度不超过90%。由于温度变化发生在产品上的凝露情况必须采取相应措施;
    4. 污染等级:3 级;
    5. 与垂直面的倾斜度不超过±22.5℃;
    6. 无显著摇动、冲击和振动地方。
    1. Ambient temperature: maximum +40℃ ,24h does not exceed the average of +35℃ ; limit is -5℃ ;
    2. Altitude: not exceed 2000m;
    3.Atmospheric conditions:at the highest ambient air
    temperature is +40℃ less than 50%; at a lower temperature allows a higher relative humidity, the wettest month of the monthly average minimum temperature does not exceed +25℃ ,the month The monthly average maximum relative humidity of not more than 90%.Due to temperature changes occurred in the situation on the product condensation must take appropriate measures;
    4. Pollution Level: 3;
    5. And the vertical gradient of no more than±22.5℃ ;
    6. There was no significant shake, shock and vibration areas.

    型号Model CJ19-32
    CJ16-32 ①
    CJ19-43
    CJ16-43 ①
    CJ19B-32
    CJ 19-32 ②
    CJ19B-43
    CJ19C~43 ②
    CJ19B-63
    CJ19C-63 ②
    可控电容器 400V
    Controlled
    capacitor400V
    容量
    Qnkvar Output
    18(16) 20 15 20 32
    额定电流InA
    Rated current(A)
    26(23) 29 21.6 29 46
    约定发热电流IthA
    Conventional thermal current Ith A
    32 43 32 43 69
    抑制涌流能力
    Controlling capability to surge alrrent
    20ln
    线圈
    Coll
    工作电压US 50Hz
    Working voltage US
    50Hz V
    220,380 或按用户要求
    220,380 or According to the requirements of users
    动作范围
    Operating range
    0.85-1.1 Us
    消耗率VA 起动
    Start consurmed
    power(VA) holding
    吸特holding
    68 12 115 11 200 20
    短路保护熔断器额定电流选定
    Rated current for short-circuit
    Protectedfuse
    1.5-2.5ln
    额定绝缘电压 Ui 50Hz V
    Rated insulation voltage Ui 50Hz V
    500 660
    辅助触头约定发热电流A
    Conventional heating current of auxiliary
    contacts A
    10
    机械寿命万次
    Mechanical life ten thousand times
    100 80
    电寿命操作频率120 1/h 万次
    Electrical life operating freauency 120 1/h
    thousand times
    10 8
    重量 kg
    Weight kg
    约 0.58 About 0.58 约 0.57 About 0.57 约0.6 About 0.6 约 1.25 About 1.25  
    接触器型号
    Contactor model
    CJ19-25、32、43 CJ19B-32、43/CJ9C-32、43 CJ19-63 CJ19B-63/ CJ9C-3
    辅助触头
    Auxiliary contact
    20E 02E 11E 21E 12E
    数量Quantity 常开( 动合)
    Nomal open(make)
    2 - 1 2 1
    常闭( 动分)
    Nomal close(break)
    - 2 1 1 2
    标志Mark
    13,14, 23,24 - 13,14 13,14, 33,34 13,14
      11,12, 23,24 21,22 21,22 21,22 31,32
    注:① CJl6 型可以用CJl9 型代替。
    ② CJl9C 型的基本技术性能与CJ19B 型相同, 不同之处为电阴电路在完成抑制涌流作用之后即与电路脱离。
    Note: ① Model CJl9 can substitute for Model CJl6.
    ② The basic technical function of model CJl9C is the same as model CJl9B,but the difference is that the former will switch off the circuit after its resistor circuit finishes controlling surge current.
  • 问:质量怎么样?
  • 答:我们的产品经过国家电力电容器质量监督检测中心检测合格,并且是同行业中率先通过ISO90001:20000质量体 系认证的企业。
  • 问:电容器运行中会不会发生爆炸?
  • 答:只要严格安装说明书使用,安装电容器专用熔断器,爆炸就不会发生。
  • 问:公司规模如何?
  • 答:公司创建于1996年,注册资金550万,拥有标准厂房8000余平方米。
    1.我公司生产的每台产品在出厂前都经过严格的检测,产品的质量合
    格率在99%以上,另外我们对产品保用一年,只要在一年内有质量问
    题可以包修包换包退。
    2.一般在不影响下次销售的话,可以退货。
    3.只要严格安装说明书使用,安装电容器专用熔断器,就不会发生爆
    炸等情况。